05:41am Thursday 19 October 2017

Over 95% of medical residues can be purified from wastewater

Generally speaking, drugs that act on the mind and the heart are the most difficult to remove.

professor Mika Mänttäri

Researchers tested the removal of drug residues using membrane filtration and oxidation. The results show that these technologies remove 95% and, in some cases, up to 99% of contaminants and nutrients. If they enter the water system, even very small concentrations of contaminants can damage the water ecosystems, for example, through hormonal changes in fish.

The research results show that more efficient water cleaning technologies, such as membrane filtration and oxidation, effectively remove substances that are normally difficult or impossible to remove in a biological cleaning process. Such substances include drugs for depression and epilepsy and pain gels that are applied externally.

“Generally speaking, drugs that act on the mind and the heart are the most difficult to remove,” says LUT Professor Mika Mänttäri, who was responsible for the study.  

The research also demonstrated that increasing the efficiency of water treatment can also filter certain nutrients from the water. For example, phosphorous and nitrogen can be almost completely removed from the water. Membrane filtration reduced the amount of phosphorous to one tenth or even one hundredth of the emissions currently permitted. The water cleaning technologies that were tested can thus reduce emissions significantly in comparison to the water treatment process that is traditionally used.

The wastewater cleaning process used today in nearly all municipalities only removes the substances that are readily biodegradable or which bind to the activated sludge in the process. Such substances include pesticides and basic pain medications that contain ibuprofen, paracetamol and ketoprofen. The process allows a lot of other non-biodegradable contaminants to pass through.

At this time, Finland does not have any wastewater treatment plants that are designed especially to filter drug residues out of the water. The situation is complicated by the fact that Finland does not have any general limit values for contaminants in the water and, subsequently, no obligations to monitor or remove such substances. This means that existing wastewater treatment plants have no obligations or incentives to invest in new technologies.   

In the near future, the EU will make large treatment plants subject to monitoring requirements for certain priority substances. A monitoring requirement was already set for some substances last autumn. One of the substances being monitored is the anti-inflammatory drug diclofenac, which is used as the active ingredient in pain gels. Once the limit values are implemented, the current biological process will automatically be in trouble.

However, many municipalities are already discussing how wastewater treatment should be arranged in the future. The LUT researchers estimate that the next 5–10 years in Finland will be a transition phase to more efficient cleaning, as the environmental permits for many municipal treatment plants expire and the permit conditions become stricter over the next decade.

Although more efficient water cleaning technologies are already available, their implementation requires longer-term tests in the right environment. Laboratory testing with model substances is not the same as using real waste water in a water treatment plant. The LUT research was made possible by the municipality of Parikkala, which allowed on-site piloting with real waste water.

Mänttäri emphasises the importance of piloting possibilities when implementing new technologies. He also sees them as opportunities for Finnish companies.

“These types of demonstration platforms could allow Finnish companies to test their own water treatment technologies for international markets,” says the professor.

 
Further information:

Mika Mänttäri, Professor, mika.manttari@lut.fi, +358 40 734 2192.

Mari Kallioinen, Associate Professor, mari.kallioinen@lut.fi, +358 40 593 9881.

Kimmo Arola, Doctoral Student, kimmo.arola@lut.fi, +358 50 373 4447.

Photos: http://lut.pictures.fi/kuvat/LUT+Press+Images/MBR-vedenpuhdistus/
 

 

Improving the efficiency of the current wastewater cleaning process can remove more than 95% of contaminants, such as drug residues and pesticides, from water. These are the findings of research performed at Lappeenranta University of Technology (LUT).

Generally speaking, drugs that act on the mind and the heart are the most difficult to remove.

professor Mika Mänttäri

Researchers tested the removal of drug residues using membrane filtration and oxidation. The results show that these technologies remove 95% and, in some cases, up to 99% of contaminants and nutrients. If they enter the water system, even very small concentrations of contaminants can damage the water ecosystems, for example, through hormonal changes in fish.

The research results show that more efficient water cleaning technologies, such as membrane filtration and oxidation, effectively remove substances that are normally difficult or impossible to remove in a biological cleaning process. Such substances include drugs for depression and epilepsy and pain gels that are applied externally.

“Generally speaking, drugs that act on the mind and the heart are the most difficult to remove,” says LUT Professor Mika Mänttäri, who was responsible for the study.  

The research also demonstrated that increasing the efficiency of water treatment can also filter certain nutrients from the water. For example, phosphorous and nitrogen can be almost completely removed from the water. Membrane filtration reduced the amount of phosphorous to one tenth or even one hundredth of the emissions currently permitted. The water cleaning technologies that were tested can thus reduce emissions significantly in comparison to the water treatment process that is traditionally used. 

The wastewater cleaning process used today in nearly all municipalities only removes the substances that are readily biodegradable or which bind to the activated sludge in the process. Such substances include pesticides and basic pain medications that contain ibuprofen, paracetamol and ketoprofen. The process allows a lot of other non-biodegradable contaminants to pass through.

At this time, Finland does not have any wastewater treatment plants that are designed especially to filter drug residues out of the water. The situation is complicated by the fact that Finland does not have any general limit values for contaminants in the water and, subsequently, no obligations to monitor or remove such substances. This means that existing wastewater treatment plants have no obligations or incentives to invest in new technologies.   

In the near future, the EU will make large treatment plants subject to monitoring requirements for certain priority substances. A monitoring requirement was already set for some substances last autumn. One of the substances being monitored is the anti-inflammatory drug diclofenac, which is used as the active ingredient in pain gels. Once the limit values are implemented, the current biological process will automatically be in trouble.

However, many municipalities are already discussing how wastewater treatment should be arranged in the future. The LUT researchers estimate that the next 5–10 years in Finland will be a transition phase to more efficient cleaning, as the environmental permits for many municipal treatment plants expire and the permit conditions become stricter over the next decade.

Although more efficient water cleaning technologies are already available, their implementation requires longer-term tests in the right environment. Laboratory testing with model substances is not the same as using real waste water in a water treatment plant. The LUT research was made possible by the municipality of Parikkala, which allowed on-site piloting with real waste water.

Mänttäri emphasises the importance of piloting possibilities when implementing new technologies. He also sees them as opportunities for Finnish companies.

“These types of demonstration platforms could allow Finnish companies to test their own water treatment technologies for international markets,” says the professor.

 

Further information:

Mika Mänttäri, Professor, mika.manttari@lut.fi, +358 40 734 2192.

Mari Kallioinen, Associate Professor, mari.kallioinen@lut.fi, +358 40 593 9881.

Kimmo Arola, Doctoral Student, kimmo.arola@lut.fi, +358 50 373 4447.

Photos: http://lut.pictures.fi/kuvat/LUT+Press+Images/MBR-vedenpuhdistus/

– See more at: http://www.lut.fi/web/en/news/-/asset_publisher/lGh4SAywhcPu/content/over-95-of-medical-residues-can-be-purified-from-wastewater#sthash.d5ZQiKBl.dpuf


Share on:
or:

MORE FROM Environmental Health

Health news